过滤器
发布时间:2019-09-17
1. 对于小型的净化设备,如洁净工作台、层流罩等,由于处理的风量小,一般新风进风面采用初效过滤器或中效过滤器,送风末端必须选用高效过滤器或超高效过滤器;风淋通道因处理风量大一般选用亚高效过滤器。
2. 对于净化空调系统中空气过滤器的选用与配置,一般根据洁净室的空气洁净度级别和生产工艺的特殊要求,进行合理化选用与配置。
A. 对于1000-10万级别的洁净室净化系统,通常采用三级空气过滤形式,即初效、中效、和高效过滤器;初效、中效一般放在空气处理装置(送风柜)中,且将中效过滤器放在正压段,亚高效或高效过滤器一般位于净化空调系统的末端。
B. 对于100-1000级的净化空调系统,通常在新风处理装置中设置初效、中效、亚高效过滤器,在洁净室循环风系统中,还要设置高效过滤器或超高效过滤器;一般的高效过滤器位于净化空调系统的末端,即位于洁净室的顶棚上;对于超高效过滤器,则必须要设在净化空调系统的末端,以确保所需的空气洁净度级别要求。
3. 当已知整个净化系统的空气处理风量时,可根据所选过滤器的额定风量,确定所需过滤器的个数。
Air Filter Selection Guide 过滤器选用指南 | |||||
Category 类别 |
Primary efficiency 初效过滤效率 |
Medium efficiency 中效过滤效率 |
Sub-high efficiency (V-bank) 亚高效过滤效率 |
High efficiency (HEPA) 高效过滤效率 |
Ultra high efficiency (ULPA) 超高效过滤效率 |
E. Level 欧洲标准 |
G1, G2, G3, G4 | M5, M6, F7, F8, F9 | E10, E11, E12 | H13, H14 | U15, UI6, U17 |
Typical Filtration Control 典型过滤控制 |
The particle>5μm Clean dust, pollen, mites, Sand dust, spray paint, fiber dust, willow catkins 粒子>5μm 清扫扬尘、花粉、螨虫、沙尘、喷漆、纤维尘、杨柳絮 |
The particle 1-5μm. General dust. Most microorganisms. Welding smoke. Pollen. 粒径1-5μm. 普通灰尘、大多数微生物、焊接烟、花粉 |
The particle0.3-5μm. Air microorganism. Cigarette smoke. 粒径0.3-5μm. 空气微生物, 香烟烟雾 |
All particles. All air microorganisms. 所有颗粒物 所有空气微生物 |
All particles. All air suspensions. 所有颗粒物 所有空气微生物 |
Examples of application 应用实例 |
Pre-filter for Class F filters, Minimum filter requirement, General public building, General Residential, Protection of air conditioning systems (air conditioning fresh air, return air) Pre-filter of Chemical Filter F级过滤器前置预过滤器 最低过滤要求 公共建筑、住宅 保护空调系统(空调新风、回风) 化学过滤器的预制过滤器 |
Better public building. Better home, workshop. Ward, treatment room. HEPA pre-filtration. Protective air conditioning system. Paint workshop shed into the wind. 较好的公共建筑、住宅、车间 病房、诊疗室 高效过滤器预制过滤 保护空调系统 油漆车间棚进风 |
Pre-filtration of ULPA and HEPA. The impure environment of the GMP 300,000 class plant. 高效和超高效过滤器的预制过滤 GMP 30万级厂房的非洁净环境 |
ISO5-ISO8 Clean room high efficiency filter. Defense industry high efficiency filter. P3 laboratory exhaust. Clean operating room. Clean workbench. Permanent ULPA pre-filtering. ISO5-ISO8洁净室高效过滤器 国防工业高效过滤器 P3实验室排风 洁净手术室,洁净工作台 永久性超高效过滤器的前置过滤 |
ISOS-ISO4 clean room microbial electronic clean room. High cleanliness requires ultra-clean workbench. ISOS-ISO4洁净室微生物电子洁净室 高洁净度要求超净工作台 |
Filter type 过滤器类别 |
Nylon mesh, aluminum mesh filter. panel type and bag type filters. Disposable panel filter. 尼龙网、铝目网过滤器 板式、袋式过滤器 一次性平板过滤器 |
Bag filter, pocket filters W type non-separator filter. Separator filter. 袋式过滤器 W型无隔板过滤器 有隔板过滤器 |
W type non-separator filter. Separator filter. non-separator filter. W型无隔板过滤器器 有隔板过滤器 无隔板过滤器 |
Non-separator high efficiency filter High efficiency filter with partition 无隔板高效过滤器 有隔板高效过滤器 |
Non-separator panel high efficiency filter 无隔板平板高效过滤器 |
Photo Ref. 参考图片 |